Recent content by sierradmax

  1. sierradmax

    Troubleshoot a "once fire" and now "no-fire" scenario"

    True. I wonder how many sensors share the 5v circuit & ground as the cam/crank sensor? Looks like more FSM book time..
  2. sierradmax

    Troubleshoot a "once fire" and now "no-fire" scenario"

    Did a little bit of troubleshooting. Zero power to injector fuse and O2 fuse in PDC. I now understand this is powered thru the ASD relay. ASD relay fuse is good and constant power is present at the relay. Ignition power is present at opposite end of coil terminal for ASD relay, when ignition is...
  3. sierradmax

    Troubleshoot a "once fire" and now "no-fire" scenario"

    Did a gauge cluster test. "Bus B1", "Bus B8" and "Panel Open".. b1 is SKIM - SKIM Message, b8 is ACM - Airbag Message, Panel Open is Panel Sense - Open Circuit (related to the panel lamps dimmer circuitry of the left multi-function switch on the panel lamps dimmer signal circuit)
  4. sierradmax

    Troubleshoot a "once fire" and now "no-fire" scenario"

    Yes it does. The SKIS indicator flashes on start up for bulb test then goes off after a few seconds. It's my understanding that if flashing or remaining on, it's an indication of SKIM fault, right?
  5. sierradmax

    Troubleshoot a "once fire" and now "no-fire" scenario"

    Yes, that's correct. I'm going to check camshaft sensor.
  6. sierradmax

    Troubleshoot a "once fire" and now "no-fire" scenario"

    Yes, it ran prior to pulling.
  7. sierradmax

    Troubleshoot a "once fire" and now "no-fire" scenario"

    I swapped a running & driving 03 5-speed donor into another jeep. Everything except the tub, transfer case, frame, and axles are from the 03. Dash, ignition, fuel, PCM, wiring harness, etc. is all from an 03. At crank, it started, ran rough for about 5 seconds then died. Following, a crank but...
  8. sierradmax

    Stretched TJK (bigger rubber & extra inches)

    Well, I reassembled the JK front and have about 100 miles on it. So far, so good. However, this arrived this week. nearly 5 months since ordering.
  9. sierradmax

    Rhode Island 3/16" thick brackets for TK1-racing rear sway bar system

    These are "minimalist" brackets I designed & cut that can be used to mount Tony's TK1-Racing offroad sway bar to the rear of a stretched TJ (factory rear frame stretch) or a LJ. TK-1 Racing sway bars can be purchased here: https://store.tk1racing.com/ProductDetails.asp?ProductCode=120%2D00...
  10. sierradmax

    Emissions readiness reset

    My state requires emissions testing for inspection purposes on vehicles 25 years old and newer. This is done every two years. Since I've owned my 05, it's always given me issues when it comes time for inspection. I performed TSB # 25-005-13 two years ago and was able to get it to pass after...
  11. sierradmax

    Rhode Island 03-06 seatbelts & hardware

    Good condition. Pulled from an 03 & they all function. Hardware included. Includes rear seat buckle(s) but NO FRONT buckles.
  12. sierradmax

    Single brake line to each axle: Which outlet on the proportioning valve?

    I'm running a single brake line to each axle. Out of the two ports off the side and one off the rear, which should be used and which one should be blocked? Or does it matter?
  13. sierradmax

    Has anyone converted their fuel lines to flex?

    Genright tank is in and I don't feel like fighting factory supply and evap hard fuel lines through the labyrinth of crossmembers, link mounts, etc.. Has anyone replaced with flex lines? What adapters are needed to go from factory fittings to -AN? It's an 05'.
  14. sierradmax

    Dana 44 disc backing plates

    In need of a set of backing plates that have rotted. Not looking to spend $700 for used ones off Ebay. Has anyone tried Dorman 924-657? Even these are priced high for some thin stamped pieces of metal. https://www.amazon.com/dp/B07CZB3446/?tag=wranglerorg-20
  15. sierradmax

    Thread/Pitch Spreadsheet?

    Does anyone have an ongoing chart or spreadsheet with bolt/nut thread pitch for the TJ? Specifically for the body. I.E. tub, fenders, grille, tialgate, etc.