Search results

  1. AceShooter

    Control arm advice

    So looks like I’m out of commission. Just noticed my front passenger lower control arm just doesn’t look right. Currently have a 2” RC suspension and 3” BL. Both PO Long term plan is to swap out the RC for a proper suspension lift in the 4” range and either lower the BL to 1” or eliminate all...
  2. AceShooter

    How much lateral movement should be in the rear sway bar?

    How much lateral movement should be in the rear sway bar? I noticed today that I can grab the rear sway bar and move 1/4”+. Also noticed my axle end of my track bar as a slight amount of play in it. Frame side is solid. Question here would the play in the track bar be magnified in the steering...
  3. AceShooter

    Weird beeping while driving

    So just happened and can’t get it to go again. Drove for about 10 miles, was driving about 45mph in 4th gear, downhill not much gas. All of a sudden I started hearing a beeping noise. Same noise when you leave parking brake up. Checked parking brake and it was down all the way. Started to...
  4. AceShooter

    Transfer Case???

    So this doesn’t look like stock 232 transfer case I’ve seen online. Any ideas what it is or is it stock?
  5. AceShooter

    Throbbing Steering

    So I noticed yesterday that at higher speeds, 55mph+. The steering has a noticeable throbbing/pulsing sensation. Right at the edges of the slop in the steering wheel. I upgraded to the ZJ tie rod and replaced everything back to the pitman arm. Toe-In was set at 1/16” in. The slop in the...
  6. AceShooter

    Switched Power

    Working on some electrical stuff today. PO went crazy with wiring behind the switch panel. Does anyone know how to run switched power to the cigarette outlet. I was able to locate the battery feed but there’s no wires for the second keyed outlet. 2004 Sport I do have the switches for...
  7. AceShooter

    Manual Shifter Adapter

    So moving onto my next opportunity. 1st is difficult to get into, not impossible just not as easy at 3rd or 5th. From looking around it appears that I have a spacer on top of the transmission and from what I think is some type of shifter extender. Body lift is 2.5” (hopefully soon to...
  8. AceShooter

    Door stuck

    So just when I think I have things finished up this pops up. Passenger door will not open unless you either press in on the interior unlock switch or have a key in the lock applying slight pressure in the unlock position. I’ve sprayed everything down and even went as far as bending/tweaking...
  9. AceShooter

    Removing Body Lift

    So based on my measurements I have a 2.5” suspension lift and and 2” body lift. Running 35’s. I’d like to bring the body lift down or possibly remove all together. One suggestion would be to remove the body lift spacers and cut them to length and the install proper length bolts. Other...
  10. AceShooter

    Is this pitman arm and track bar mount stock?

    So finished up the ZJ conversion and replaced Steering Dampner and Draglink just since I was half way there and all the bushings were bad anyway. Steering improved dramatically. Was checking torque after a couple days of driving and thought I’d run these by you guys. I’m thinking both the...
  11. AceShooter

    Parting out dashboard

    Remaining Dash being parted out. Items marked in red are already spoken for or sold. Center vents are usable but both have issues with a vertical piece
  12. AceShooter

    Air Compressor Recommendations?

    Does anyone know of a good/decent cigarette powered air compressor for airing back up after airing down? Currently running 35” Sent from my iPhone using Tapatalk
  13. AceShooter

    Steinjager Cable Shifter

    Was about to order a Savvy transfer case cable shifter and found the Steinjager brand cable shifter. About $30 less than the Savvy but was curious if anyone has tried or had experience with it. With the Novak and Savvy so closely priced I’m curious if the Steinjager is using a cheaper cable...
  14. AceShooter

    Azzy Z-Link Transfer Case Linkage Kit

    Has anyone tried this replacement for the Z linkage on the transfer case? https://www.azzysdesignworks.com/store/jeep-np231-transfer-case-linkage-kit Sent from my iPhone using Tapatalk
  15. AceShooter

    Help Getting Transfer Case Linkage Back Together

    Can someone give me some tips/tricks on getting my transfer case linkage back together? Sent from my iPhone using Tapatalk
  16. AceShooter

    2004 Wrangler Sport!

    New member/owner of a 2004 Wrangler Sport. Just picked up yesterday and already starting my "To Do" list. Brief Description 2004 Wrangler Sport 4.0L 6 Cylinder 3 1/2 Suspension Lift 2 1/2 BL Quick Disconnect Sway Bar Dana 30/Spartan in Front Ford 8.8 in Rear 4.56 gears Cold Air Intake 35"...