Search results

145,000 miles on a 2004 TJ and Check Engine Light comes on. Turn ign. key 3 times and get P0138 code. Am looking to replace all 4 O2 sensors based on the recommendations on this site. Some of the O2 sensors list NTK as the manufacturer and NGK as the brand on the spec. sheet. Here are the...

Anyone have the part number or know where I can get the captured nuts that slide under the lip of the tub that the hard top is fastened down with? There are 3 per side with a total of 6. Thanks in advance.

I bought a steering box skid plate and am having a hard time removing the bottom bolt to install the skid. Squirted Kroil on the threads over several days. I first tried a socket wrench with no success. Tried an impact gun with no success. It is a hardened bolt but I don't want to risk snapping...

I see where Ford will be debuting Bronco in a couple of days. Anyone have any info. on this? Thoughts?

2004 Jeep TJ with NV3500 5 speed manual trans.. I changed my transmission fluid recently and found metallic whiskers attached to the magnetic drain plug. I know this is normal but is there any way to gauge if the amount is too much or about average?

I have a 2004 TJ I6 with NV3500 manual trans., 4.56 gears, Detroit Tru Trac LSD rear, 33" tires. I seems like my TJ is being held back during acceleration, almost like it is governed for lack of a better description. My comparison is that my 1995 XJ I6 automatic trans. seemed to have more top...

2004 TJ, I6 with 5 speed manual. When cold I get a high pitched squeal when I get to around 2500 rpms., all gears. Push in the clutch noise goes away or let up on throttle noise goes away. Once engine & trans. warmed up, no squeal. Any ideas? Thanks in advance.

http://www.nbcnews.com/id/29534497/ns/us_news-environment/t/billion-later-nuclear-waste-site-dead-end/ Years later there are still no plans for the long term storage of our commercial nuclear reactor's spent fuel or reprocessing. Every commercial nuclear plant in the U.S. has to store it's...

Anyone familiar with these? I'm looking for a 2004 TJ with a Bestop NX Trek soft top but don't want to pull the trigger until I hear some positive reviews. https://hotheadheadliners.com/

I just had my 2004 TJ re-geared which included new axle seals, bearings, pinion seals & nuts, etc.. Broke the gears in properly and re-filled the diffs. with non synthetic fluid (Chevron Delo ESI 80W-90) since I had a Tru Trac LSD installed in the rear. Just the other day I noticed the rear...

I have a 2004 TJ 5 speed manual with the NV3500 gear box. I bought it in March, 2019 and have only put 3,400 miles on it but driven it enough to get a feel for it's unique characteristics. Changed all the fluids when I first bought it and used Amsoil Synchromesh fluid for the trans.. Drove...

I am curious to see what at how many RPMs others shift at. My 2004 TJ 5 speed has a NV3500 gear case. My tires are 33 X 12.5 X 15" with 4.56 gears. I usually shift up close to 3,000 RPMs and seem to only need 5th when on long highway stretches. What do others do with the same set up? Comments...

Check this out: https://www.amazon.com/dp/B07K22DGRY/?tag=wranglerorg-20

I have a 2004 TJ I bought this past March that already had 4" of lift along with a very stiff suspension from PO. It is a 5 speed Sport with 33" tires, 4.56 gears and a Detroit True Trac LSD in rear, open diff. in front, 1" body lift and a skid plate 1" lower. This is more than I need and don't...

I have a 2004 TJ that I bought with 4" of lift and a transfer case lowered 1". Recently re-geared to 4.56 gears, running 33" tires. I am going to have a SYE installed, new rear drive shaft and adjustable upper control arms. The shop is going to use Advance Adapters SYE, Tom Woods rear shaft and...

Yesterday I stopped by the local Jeep dealer to look at several new Gladiators on the lot. It was Sunday so I did not have a sales person bore assing me to death. Gotta admit the Rubicon looked pretty good and had many appealing features. Anyone test drive or have opinions on the Gladiator?

Can the SKIM system be by passed by a thief taking jumpering the ignition switch or other common methods. I have a 2004 TJ Sport with the SKIM system and was wondering if I need to install any other safe guards to prevent theft. Disregard question; already have answer.

I worked on several projects involving the use of Cor Ten steel. This steel is designed to develop a surface layer of rust, forming a protective layer for the steel underneath. Once this protective layer of rust is formed there is no further degradation of the base metal. A frame made out of...

At some point in the future I will be looking to replace the NV3500 5 speed trans. in my TJ. A fellow Jeeper bought a trans. from this company called The Terminator. Anyone familiar with this company or have any thing to add?

O.K., one last time for any input and for confirmation I am making the right decision. I have a 2004 TJ 4.0l, NV3550 5 speed trans. with 33" tires and 3.73 gears, Dana 44 rear, Dana 30 front. Shifting on the road is less than desirable, especially going up hills. This will see some off road...