Search results

  1. R

    Brief Metal Knocking Noise After Fully Compressing the Clutch When Driving

    Hi, My 2002 Jeep Wrangler with 185000 miles has a brief knocking noise that starts loud and quiets for 1-2 seconds once the clutch disengages from the flywheel. I am not sure if it is related, but when I am driving and release the gas without pushing in the clutch, the jeep catches and harshly...
  2. R

    EVAP Code

    My Jeep has been displaying an EVAP Engine code P0456. The engine light appears once i reach roughly 3/4 tank of fuel and then goes away once I reach the reserves. I have read other forums regarding this code but none of them specified when it turns on and off. Is this a sign of a specific fix...
  3. R

    Serpentine Belt Screech

    I just replaced the water pump in my 2002 Jeep Wrangler 4.0, right after install it started to make a squealing/screeching noise. I figured it was just wet from coolant and would eventually go away, but it has been a few days and its seeming to get worse. I attached a video of the sound its...
  4. R

    Pulsating and Jerking Steering Wheel at Low Speeds

    I have a 2002 Jeep Wrangler 4.0 and recently whenever I turn at slow speeds, under 10 mph, the steering wheel pulsates /jerks until the wheel is straight. I checked the power steering fluid level and its a little low, about a half inch from the "add" line on the dipstick when cold. Any Ideas...
  5. R

    Necessary Suspension Component Upgrades for Lift Kits

    I have a 2002 Jeep Wrangler Sport and installed a 2" Pro Comp suspension lift kit. The lift came with no additional control arms or suspensions components of that sort to accommodate the lift. I did not think that those parts would be necessary considering it is only a 2" lift, however, I have...
  6. R

    High speed vibrations after lift install

    I have a 2002 Jeep Wrangler that has a Pro Comp 2 inch lift with 32 in tires. Ever since the lift and tires there has been a vibration, mainly from my seat and center console, that starts at 50mph and gets worse and worse as I go faster to the point where the vibrations shake the mirrors where I...
  7. R

    4.0 engine tick / knock on when cold

    I drive a 2002 Tj with a 4.0 and it has had a small tick after a few seconds after a cold start and it comes and goes until it is totally warm. Just recently I started the cold engine and it produced a much more violent tick almost like a knock, the engine ran much less smooth as well. I shut...
  8. R

    Oil leaking from the valve cover breather?

    I changed my oil roughly 2000 miles ago and I recently checked my oil and found that I was 1.5 qts low. I have had trouble with oil leaks from the valve cover gasket so I replaced it, and it seems to be holding up ok, I think. Since replacing the valve cover gasket and cleaning the valve cover I...
  9. R

    Broken Body Mount Bolt

    The rear passenger side body mount bolt broke off. I was thinking I could cut a hole in the floor pan directly above the body mount so I can cut the bolt and drill it out and replace the hardware, is this possible? What would be the best way to go about fixing this problem?