Transfer Case Shaft Snap Ring Suggestions?

4BY4ADV

TJ Enthusiast
Original poster
Supporting Member
Joined
Jan 2, 2020
Messages
280
Location
Oceanside, CA
I'm beating myself up trying to remove the snap ring from the transfer case shaft. The snap ring has angled ends that every set of snap ring pliers I use either slip off of... or the ends slip inward onto a tooth of the gear and I get stuck. Before I start throwing things... anyone have a suggestion?

No holes near the ends for a snap ring plier to bit into...
 
sears hardware craftsman # 49273 is the marking

109936429_317985692906899_3561240618708665141_n.webp


115505293_662834144329431_4272361346666798982_n.webp
 
And I feel like an idiot. Thanks!

Dang. Wish Harbor Freight had a pair. I'm two blocks away.
 
You might be able to find those cheaper Lisle ones locally at an auto parts store. They will likely cost more than amazon sells them for.
 
Removed the retaining ring. I'm the lucky owner of an earlier NP231(was already thinking that was the case due to the different drain and fill plugs).

Without a press.... anyone have suggestions for removing the needle bearings? I was thinking a socket, C clamp, and a couple blocks of wood, but even my 36mm socket isn't big enough.

Should I be getting this? https://www.harborfreight.com/3-jaw-pilot-bearing-puller-4876.html
 
No, my issue is that I have an earlier NP231J. There are needle bearings on the drive sprocket that aren't used on the new short shaft. Instructions say to remove the bearings... and all the videos I've seen show people using a hydraulic press.

I've seen people use large sockets to and clamps to remove bearings from other parts, but I'm not sure I'll be able to pull that off.

I hate to spend $150 on a press that I'll likely only use once. But that just might be what I have to do.
 
  • Like
Reactions: hosejockey61